Inspection Report
Woodshed II
430 N DOBSON RD MESA AZ 85201
FD-23-02465
Food Establishment - Eating & Drinking
Food Review Inspection
12/14/2023
0
Completed
Violations
Violation #: 1
Description: Plumbing and Backflow (FD PR)
Comments:
1) Replace the pull out sprayer faucets at the mop sink and prep sink with rigid, swing faucets to provide an air gap backflow. Provide a hose bib vacuum breaker for any hose bib faucet at the mop sink.
2) Provide 1" minimum air gaps to all indirect drains going to floor sinks, as needed.
3) Plumb the drying shelf unit at the bar to the floor sink and provide a 1" minimum air gap. Ensure rigid piping is utilized.
4) Provide hot water to the bar dump sink measuring 110' F minimum. The sink currently only has cold water plumbed.
:
Violation #: 15
Description: Other (FD PR)
Comments:
1) Provide a 3/8th inch minimum cove base to floor/wall and millwork/floor junctures at the kitchen, cook line area, restrooms, and bar area, as needed. Recommend rubber cove base. A metal cove base is required at the ventilation hood floor/wall junctures.
2) Refinish all damaged and scuffed wall areas with semi-gloss paint, as needed.
3) Caulk-in all wall holes, plumbing penetrations, and escutcheon plates throughout the facility with silicone. Observed a large wall opening next to the mop sink that needs to be finished.
4) Ensure all bottom shelving pieces at shelving units are provided with a 6" minimum clearance from the floor.
5) Provide splash guards around the prep sink to prevent contamination. The splash guards must match the length of the sink and height of the faucet.
6) Replace the damaged laminate wall boards holding wall shelving units. The laminate countertops are the back bar area are not approved. Please provide a clear epoxy sealer to the countertops.
7) Conduct a deep clean under sink fixtures and bar equipment.
8) Refinish the rusted areas of the walk-in cooler and replace the rusted shelving units in the walk-in cooler.
9) Flash off the gaps where the ventilation hood meets the walls.
10) Resurface or replace the cutting board at the refrigerated make table.
11) Caulk the bar countertop/wall gaps with silicone.
12) Provide a sneeze guard at the expo line to prevent contamination from customers sitting nearby at the bar.
13) Replace the torn refrigerator door gaskets, as needed.
14) Provide a smooth and flush finish around the floor sink located under the warewash machine. Observed open concrete.
15) Provide smooth, washable ceiling tiles to the restrooms and above the mop sink. Observed perforated acoustical ceiling tiles.
16) Provide a clear matte sealer to the wood wall panels in the restroom and fill all gaps between panels with caulking.
:
Comments/Details
This establishment/operation has demonstrated sufficient compliance to proceed with the issuance of the permit. To complete the permitting process, issuance of this permit, and begin operation, the applicant must first submit payment of the annual operating permit fee to the Department’s Administrative Services. Fees paid up to this inspection approval do not include the annual operating permit fee. PAYMENT with a credit/debit card can be made via phone at 602-506-6824, Option 2.
Per MCEHC Chapter I, Regs 4 & 5, no person shall conduct an operation or operate an establishment for which a permit is required without holding the necessary and valid permit to do so. Payment with a credit/debit card can be made on-line via select “Pay a Fee” at esd.maricopa.gov. Please note that if you select payment via online, the annual operating permit fee invoice may take up to 7 business days to post online. Also, checks and money orders are accepted via US Mail. If you select payment via US Mail, for further instructions please refer to the printed invoice. No operating permit is valid, until the permit fee is received by the Department. It is the responsibility of the permit holder/owner to notify MCESD if there are contact/ billing address changes.
On July 1st, 2023, the Environmental Services Department started emailing permit card(s) and permit
invoice(s) to permittees. We need a current and accurate email address on file to ensure you receive a
copy of your permit card and invoice(s) upon renewal.
If you are unsure whether your email address is accurate, you may:
• Contact your inspector using the phone number or email on your last inspection report to review, or
• Contact the Department using the email addresses below,
o Envquickservicerestaurants@maricopa.gov (facilities such as fast-food)
o Envfullservicerestaurants@maricopa.gov (facilities that are full-service restaurants)
o Envretailgrocery@maricopa.gov (facilities like grocery stores or retail food markets)
o Envspecialtyprograms@maricopa.gov (mobile food/special events/plan review)
If you need to update your email address and/or other contact information, please submit an
administrative change request form at the below website
https://www.maricopa.gov/FormCenter/Environmental-Services-16/Administrative-Change-Request-Form-181.
All listed items will be addressed under RM-11182.
MCESD inspection report was delivered via email.
No County legal action will result from this inspection.
"A" for Food Safety
Through our grading system, Maricopa County Environmental Services Department provides at-a-glance indications of how food establishments perform during food safety inspections. This system is designed to grade food establishments in terms of food safety requirements and provide recognition to those who choose to participate.
How does it work?
The issuance of grade cards to food establishments is based on voluntary participation. The person in charge, who is present during the inspection, will be asked whether they would like to participate in the Grading System. This will be decided prior to each inspection. If an establishment does not participate in the Grading System, Not Participating or NP will appear on the inspection report, and the inspection will still occur. If an establishment does participate, a grade of A, B, C, or D will be determined at the conclusion of the inspection using the Grading System chart below. Participating establishments will then be provided with a grade card that can be posted in the establishment. The status of the establishment’s grade will also appear on the Restaurant Ratings page of the department’s website.
How can I determine the grade?
The Grading System chart can be used to determine grades earned for establishments that do not participate. Grades are determined by the number of Priority and Priority Foundation violations received at the time of inspection. Violation types are defined in general terms below.
Definitions
- Priority Violation
- Major violation that directly contributes to increasing the risk of foodborne illness or injury (e.g. Food employees do not properly wash hands when required).
- Priority Foundation Violation
- Minor violation that does not directly contribute to an increased risk of foodborne illness but failure to correct this violation may lead to the occurrence of a priority violation. For example, hand washing soap and paper towels not available at hand wash sink (may lead directly to food employees not properly washing hands when required).
- Core Violation
- Minor violation that relates to general maintenance and sanitation (e.g. No sign reminding employees to wash hands).
- Cutting Edge Program
- All county food-related establishments can partner with Maricopa County to implement a proactive approach to reducing foodborne illness risk factors by implementing food safety systems that include policies, training, and verification processes. Partners enrolled in the Cutting Edge Program receive an A+ when an A is earned.
| Violation Category | Grade A | Grade B | Grade B | Grade B | Grade B | Grade B | Grade B | Grade B | Grade C | Grade C | Grade C | Grade C | Grade C | Grade C | Grade D | Grade D |
|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|---|
| Priority | 0 | 0 | 0 | 0 | 0 | 1 | 1 | 1 | 0 | 1 | 1 | 2 | 2 | 2 | more than 2 | more than 3 |
| Priority Foundation | 0 | 1 | 2 | 3 | 4 | 0 | 1 | 2 | 5 | 3 | 4 | 0 | 1 | 2 | more than 3 | more than 0 |
Any legal action for a pattern of non-compliance or permit suspension results in a D.